Single Use White Lifting Slings

Dye-free polyester bands from 0.5 ~에 5 t — the label, 색깔이 아니라, carries the rating

A single use white lifting sling is bought with the load and leaves with it. The white band is the plainest article in the 편도 슬링 범위: undyed high-tenacity polyester, a formed eye at each end or woven closed into a loop, printed with a working load limit, a length and a batch, checked once at issue and then written off against the job.

White earns its place for reasons that are mostly about the load rather than the sling. An undyed band cannot transfer dye to a white marble slab, a paper reel, a painted panel or a carton of finished goods. It shows contamination — oil, rust bleed, cement dust — exactly where a coloured band would hide it. And there is no dye lot to match, so the second bale matches the first, which matters when the same specification has to be repeated shipment after shipment.

What white cannot do is tell a rigger the capacity from across the yard. There is no white step in the colour sequence, which is why the marking on this page is specified as carefully as the webbing: on a single-trip article the printed figures are the whole record of what the band is.

White is an absence of dye, not a capacity code

Colour coding is a convention for identifying the working load limit at a glance: 1 t 보라색, 2 녹색, 3 노란색이 아니다, 4 티 그레이, 5 빨간색이 아니다, 6 브라운, 8 파란색이 아니다, 10 오렌지색. White sits outside that convention, and buyers sometimes read that as a lower grade. 그렇지 않다. It is the colour of undyed polyester, chosen because the band will touch something that must not be marked, or because the consignment has to be built to a repeatable specification with no shade to match.

The trade-off is stated plainly in the table below. On a white band the label is the only statement of capacity, so the label has to be legible in the condition the sling arrives in — after a container, after weather, after being dragged across a deck. That is a specification line on the enquiry, not an afterthought at despatch.

What the absence of colour changes

밴드, the eyes and the mark

The band is woven from 100% 고강도 폴리에스테르, 염색되지 않은, in a plain flat weave. Polyester is the default because it stretches little under load, keeps its strength when wet and does not absorb water into the weight of the sling; white polypropylene and white nylon are available where a chemical or a weight requirement points that way. Width and ply follow the figure: 25–50 mm single ply covers 0.5–1 t, 50–100 mm two ply covers 2–5 t.

• Ends — flat eye as standard, folded eye or reinforced eye where the hook is large or the eye will be dragged. 그만큼 일회용 리프팅 슬링 끝없는 루프 version has no eye at all: 밴드가 자체적으로 결합되어 있습니다., so there is nothing to place on a hook.
• Stitch — the eye is closed with a multi-row lock stitch in high-tenacity thread, with the stitch pattern and the number of rows part of the specification rather than a workshop habit.
• Mark — a sewn white label carrying the WLL for each mode, 길이, 섬유, the batch and the date, plus the same figures printed directly on the band in black. Black on white is the highest-contrast mark available, which is the practical argument for a white band on a job where the label has to be read once, correctly, by someone in a hurry.

The eye form decides how the band sits on the hook, and the two common one-way forms answer different questions. 그만큼 One-Way Webbing Sling is the flat band with an eye at each end; 그만큼 일회용 웨빙 슬링 한쪽 눈 is the version made up for a specific hitch, where one end is finished to suit the fitting that will actually be used.

The range, in figures

These are the standard builds. Length is the effective working length, measured eye to eye or loop to loop, and the working load limit is the vertical figure; the arrangement tables below give the rest.

Standard single use white slings — nominal unit weights at mid-length

Unit weights are nominal and move with the weave and the finish; the drawing governs. Wider bands, longer lengths and mixed consignments are quoted against the load rather than picked from a list. For the two sizes bought most often, the figures are set out on the 2000KG single use lifting slings 그리고 1000KG single use slings 페이지.

The arrangement decides the figure

A webbing sling does not have one capacity. It has a capacity in the vertical, another in basket, a lower one choked, and the label states each of them. The factors below are the standard mode factors for flat webbing slings: multiply the sling’s own marked WLL by the factor. 각도는 수직에 대한 다리의 각도입니다., 기사의 라벨은 항상 테이블보다 우선합니다..

Mode factor by arrangement

Two consequences matter when a white band is specified by the bale. A choked sling is weaker than the same sling used vertically, so a load that has to be choked needs a wider band rather than a longer one. 그리고 다리를 벌리면 용량이 감소합니다., which is geometry rather than material: it is answered by a spreader, by a narrower angle, or by a bigger sling, 그리고 다른 것 없이.

Where a white one-way sling is the right article

The pattern across these jobs is a load that is finished before it is lifted, and a sling that will not come back to a store where it could be re-issued.

• White goods and appliances — painted and powder-coated casings, where a dyed band can leave a mark that will not come off at the packing line.
• 종이, board and print — reels and pallets where a wet or dyed band transfers colour into the edge of the stock.
• 결석, terrazzo and white cement products — slabs and precast units judged on the face, not the arris. The technique is the same one used with a 유리 리프팅 슬링: 부드러운, wide contact and an honest edge check before the lift.
• Export pipe and tube — bands fitted before the consignment is packed, 그래서 수신측은 결코 하나를 선택할 필요가 없습니다. The pre-slung form in the container photograph above is the usual build.
• Coated coil, aluminium and stainless sheet — where the surface is the product. 에이 폴리에스터 웨빙 슬링 in undyed white keeps the contact soft and the evidence of any contamination visible.

For a consignment that is wrapped rather than hitched, the restraint is a different article: 에이 화물 리프팅 네트 or a lashing, rated for continuous tension rather than for a lift. The two duties do not transfer, and the marking on each says which one it is.

Quantity, 길이와 표시: the three lines on the enquiry

One-way slings are bought by the bale and issued by the piece, so the enquiry is arithmetic before it is engineering. Give the figure per hitch, 효과적인 작업 길이, the number of lifts in the consignment, and how the bands will be identified at the far end.

• Length is EWL — pin to pin, 눈을 마주하다, loop to loop — not the cut length of the webbing. State the convention on the order, because the two differ by the length of the eyes.
• Quantity is normally 50 bands to a bale, with cartons for mixed lengths. The total weight is worth calculating at the wider end of the range: a bale of 100 mm bands is a handling exercise before it is a lifting device.
• Marking is the record. Our reference, the batch, the WLL per mode and the date go on the label and on the band; a printed QR or a serial can be added where the consignment has to be reconciled at the destination. HS코드 630790.

One inspection, and the conditions that end the band

A single-trip sling is inspected once, 문제의, and that inspection is the only one that can change anything. 하중과 만나는 직조를 보세요., 끝 부분의 스티칭이나 슬리브에, 그리고 라벨에는. A band that fails is destroyed rather than returned to the rack, because a band that comes back will be issued again with a marking that is no longer true.

• 컷, 걸림돌, punctures or tears in the load path — including a notch at an edge that looks superficial.
• 녹는, 탄화 또는 유약, which on polyester means the fibre has been above its working temperature and no longer has the strength the label states.
• 화학적 공격: acid or alkali burns, or stiffness and discolouration after contact with a solvent.
• 고장난, worn or pulled stitching at the eye, or a distorted eye from a hook that was too small.
• A label that cannot be read. On a white band this is the whole record, so an illegible label is the same as no label.

Single use against reusable: the arithmetic

The case for a one-way band is not that it is cheap per band. It is that the costs attached to a returnable band — the return freight, the inspection register, the cleaning, the storage — disappear when the band is left with the load.

What the word changes, 그리고 그렇지 않은 것

The engineering does not change: 섬유, 직조, the factor and the length convention are specified exactly as they are on an article that will be used for years. What changes is the journey, and the fact that there is no second inspection to catch a band that should never have been issued.

자주 묻는 질문

Is white a capacity code?

아니요. The colour sequence runs violet 1 티, 녹색 2 티, 노란색 3 티, 회색 4 티, 빨간색 5 티, 갈색 6 티, 파란색 8 티, 주황색 10 티, and white is not part of it. On a white band the working load limit is the figure on the label and on the print, 그리고 아무것도.

Why specify white rather than a coded colour?

세 가지 이유: an undyed band cannot transfer colour into a light or absorbent load; it shows contamination instead of hiding it; and there is no dye lot, so repeat bales match. The cost is that nobody can read the capacity from a distance.

Is a single use white sling weaker than a reusable one?

아니요. It is made to the same 7:1 요인, proof tested and marked the same way. 여행을 설명하는 단어, 학년이 아니라.

완벽해 보이면 두 번째로 사용할 수 있나요??

That is the case the discipline exists to prevent. A single lift does not visibly age a webbing band, so a second use is an uninspected article doing a job nobody rated.

What widths and lengths are standard?

25–100 mm width and 0.5–6 m effective working length, in single or two ply. Wider, longer and mixed consignments are quoted against the load and the packing.

Does white not simply look dirty?

It does, and in clean work that is useful: 기름, rust bleed and cement dust appear where they would otherwise be invisible. On grit and concrete a white band looks old sooner, but the conditions that actually retire it are the same as on any other colour.

Can the band carry our own reference or logo?

Yes — printed in black on the band, with the batch and the WLL, and a QR or serial where the consignment has to be reconciled at the far end.

하얀색, 단방향, and endless: which word answers which question?

White is the colour of the fibre, one-way is what happens after the lift, endless is the shape. A white band can be endless or eye-and-eye, and the endless form is on its own page, 일회용 리프팅 슬링 끝없는 루프.

다음엔 어디로 갈까

관련 카테고리 및 페이지: 일회용 슬링, Single-Use Lifting Slings for One-Trip Lifts, 일회용 편도 슬링, 끝없는 리프팅 슬링, 라운드 슬링, 웨빙 슬링, 화물 리프팅 네트, 리프팅 스프레더 빔.

연락하다

리프트 슬링 리깅 주식회사, Ltd — 전화 및 WeChat 18066002268, 이메일: lift98@jslift.com, 리푸테 산업단지, 타이저우시, 장쑤성, 중국. HS코드 630790. Send the figure per hitch, 유효 길이, the packing and the number of lifts, 너비를 확인해 보겠습니다., the eye form and the marking before the bands are cut.