Single Ply Eye-Eye Webbing Sling

A single ply eye-eye webbing sling is one flat woven polyester band with a stitched eye at each end – one ply, not two stitched together. It is made in 25 mm to 300 მმ web width, reaching 1 ტ-მდე 12 ტ at a 6:1 უსაფრთხოების ფაქტორი, stretches no more than 3 % at the working load limit, is colour coded to IN 1492-1, and is supplied with effective working lengths from 0.5 მ-მდე 100 მ.

The Two Words in the Name

Eye-eye is the end configuration: the band is looped back at each end and closed with rows of stitching, so it hangs from two fittings and carries between them. ერთპირიანი is the build: one layer of webbing in the load path, where a duplex or multi-ply sling stacks two or more layers and stitches through the set.

The eyes decide how the sling meets the hook and the load; the ply decides how thick the band is, how much bulk sits at the eye, and how far up the tonnage ladder one band can go. That second question is what this page is for, because single ply stops at 300 მმ, და 300 mm is 12 t at 6:1.

Specifications

What One Ply Actually Decides

The capacity of a flat sling is set by the cross-section of load-bearing yarn, which is width x plies. One ply buys its capacity with width alone, a duplex with a second layer of the same width, a multi-ply build with several – so single ply is the simplest way to a figure, and it runs out where the web runs out, at 300 მმ.

• It is the thinnest build at a given width. One layer, so it folds tighter at the eye and passes through a smaller shackle bow or a tighter choke than the same width in duplex.
• It is the lightest. Half the layers of the equivalent duplex, which matters on a long band and on a sling that a rigger carries up a ladder.
• It is the most supple. A single ply drapes over a curved surface and follows a pipe or a rolled coil instead of bridging it, so contact is better on a round load.
• It reaches 12 t at 300 mm at 6:1. Above that the same fibre is built in multiple plies of 300-400 mm web, because a wider single band stops being practical to handle.
• It has one layer to cut. The trade-off is honest: a duplex puts a second layer between a sharp edge and the load path. Where the edge is the whole risk, the answer is a sleeve or a duplex, not a wider single ply.

Single Ply Against Duplex

Four of the five differences below are structural consequences of one layer rather than of a different fibre. None of them changes the rule that the label governs.

Ply count is not a multiplier a buyer applies by hand. Order the working load limit and the hitch; the width and the ply that reach it are stated on the drawing, and the figure printed on the band governs the lift.

Width for a Given Figure

The ladder below is the published single-ply range for flat woven polyester at 6:1. Width is not chosen freely – it follows from the figure, and the figure is the one you need per leg in the hitch you are actually using.

Read the ladder with the factor you are building to, not a single factor. At a 7:1 factor the same 300 mm web carries 10 t rather than 12 ტ, and the narrower widths move up one step each – 1 t needs 30 მმ, 2 t needs 60 მმ, 3 t needs 90 მმ, 5 t needs 150 მმ, 8 t needs 240 მმ. The 7:1 column is published on the white flat webbing sling page; the full mode-factor table is on the webbing sling category page.

Minimum length follows width, not tonnage: 0.5 m from 30 მმ, 1.0 მ-ზე 60-90 მმ, 1.5 მ-ზე 100-150 მმ, 2.0 მ-ზე 200 mm and above. These wide-band minimums are confirmed with the order.

Capacity Is Per Hitch, Not Per Tonnage

The tag gives one figure, for a vertical lift. Every other arrangement derates it, and an eye-eye sling is the build where the choke figure is most often forgotten – because both eyes look equally usable, and the simplest way to hang a bundle is to pass one end round and hook it back.

ა 5 t sling chokes 4 ტ, so a 4.5 t load choked on a 5 t band is an overload, not a margin. And a choke wears at the bearing point faster than any other part of the band, which is why a sleeved eye is worth fitting there rather than replacing the sling early.

The Eye, and What It Has To Fit

The eye is sized to the fitting it will sit in, not to the load. An eye that will not pass a bow shackle is a sling that gets knotted at the quay, and an eye that is far too large is an eye that walks on the pin. Send the hook or the shackle and the eye is made to sit in it.

The stitching is the joint, and it is what makes an eye-eye band different from an endless one: the load goes into shear across the full width of the band instead of into the last row of thread. Where a load has square edges, an eye turned through 90 გრადუსი – a reverse eye – lets the band lie flat against the corner instead of standing on its edge over it.

სიგრძე, and the Convention It Is Measured In

An eye-eye band is quoted either as the effective working length between the bearing points of the two eyes, or as the overall length including both eyes. The gap is two eye lengths – on a short band the difference between a load that hangs level and one that does not.

• Say which convention you are quoting. Effective working length is what the lift geometry needs; overall length is what the stores measure. Both are legitimate; mixing them is not.
• Eye length is part of the figure. ა 3 m band with 300 mm eyes is not the same article as a 3 m band with 150 mm eyes, even where both read 3 ტ.
• Range. 0.5 მ-მდე 100 m in this family, with the minimum set by the width rather than by the tonnage.

The Colour Is the Capacity

IN 1492-1 assigns a colour to each working load limit, which is the fastest inspection on site: if the band is yellow it is 3 ტ, whatever the paperwork says. ზემოთ 10 t no colour is assigned, because the band is too wide for colour alone to be reliable and the label carries the figure.

ASME B30.9 does not use colour coding: the tag states the working load limit and the hitch, so never infer capacity from colour on a sling built to B30.9. An undyed white flat webbing sling sits outside the code entirely: it is specified for loads that cannot take a dye transfer.

Where a Single Ply Is the Right Order

A single ply eye-eye webbing sling is not the cheap version of a duplex; it is the right build for a set of jobs. Steel pipe is the one this page is most often bought for: a pipe pack is curved and often coated, and a supple band that follows the bundle beats a stiff one that bridges it.

მარკირება, Storage and Retirement

The band of a single ply eye-eye webbing sling carries the working load limit, ეფექტური სამუშაო სიგრძე, the factor it was built to and any reference your system needs. A printed figure and a sewn label that disagree is a contradiction, არა დეტალი – where both exist they come off the same order line. Store it clean and dry, out of sunlight, off the floor and out of grit. Polyester takes water and most common chemicals well, but strong alkalis and some solvents attack it; the working limit is around 100 °C, and these fibres fail by melting rather than by deforming politely.

Inspect before every use, and formally at the interval the site rules set. Any one of those retires the band, and none of them is repairable.

ხშირად დასმული კითხვები

What is a single ply eye-eye webbing sling?

One flat woven polyester band, with a stitched eye at each end and a single layer of webbing in the load path. Not a duplex: nothing is stacked or stitched through a set of layers. It is the standard build from 25 mm to 300 mm web, carrying 1 ტ-მდე 12 t at a 6:1 ფაქტორი.

Single ply or double ply – which should I order?

Single ply for a load that needs a supple band, a slim eye on a small shackle, or the lightest sling at a given width. Duplex where a cut edge or grit is the real risk, because the second layer stands in front of the load path. ზემოთ 12 t there is no single-ply answer at all: the build goes multi-ply.

How much does a single ply webbing sling hold?

From 1 t at 25 mm to 12 t at 300 mm at a 6:1 ფაქტორი, with the minimum breaking load six times the working load limit. ზე 7:1 იგივე 300 mm web carries 10 ტ. The figure printed on the band governs, and it is the vertical figure unless the label says otherwise.

Does choking reduce the capacity of an eye-eye sling?

დიახ – to 0.8 of the vertical figure, so a 5 t sling chokes 4 ტ. An eye-eye sling makes a choke easy to rig by passing one eye through the other, which is exactly why the reduction is so often missed on site.

How is the length measured on an eye-eye webbing sling?

Either eye to eye, which is the effective working length, or overall including both eyes. Say which one you are quoting: the gap is two eye lengths, and on a short band that is enough to make a load hang unevenly.

How big should the eyes be on a webbing sling?

Big enough to pass the shackle bow or the hook it will sit in, and not much bigger. An eye sized to the fitting sits still on the pin; an oversized eye walks along it and wears at the wrong point.

Can a single ply sling be supplied undyed or printed with our own reference?

Yes to both. An undyed band is outside the EN 1492-1 colour code, so the printed figure carries the capacity; and the working load limit, the length and your own part or asset number can be printed as a production instruction, in the exact string and case you send.

Request a Quotation

Send the working load per leg, the hitch and the included angle, the effective working length eye to eye, the shackle or hook the eyes must pass, and the surface the band must not mark. We come back with the width, the ply, the eye type and the labelled working load limit – on a drawing, before anything is woven.

Send your sling specification for a quotation

Telephone / WeChat: +86 180 6600 2268 | ელ.ფოსტა: 702461526@qq.com
მისამართი: Lifute ინდუსტრიული პარკი, ქალაქი ტაიჟოუ, ჯიანგსუს პროვინცია, ჩინეთი | HS კოდი: 630790

დაკავშირებული პროდუქტები

• Polyester webbing sling – the fibre page, and the multi-ply builds above 12 ტ
• Heavy duty eye-eye flat web sling – the same build at high tonnage
• White flat webbing sling – the undyed band and the 7:1 ladder
• Nylon synthetic web sling – where the band must absorb a snatch
• Heavy eye webbing sling – a reinforced eye for a large bow shackle
• Webbing sling – the category, and the full mode-factor table
• Lifting devices – the shackles and hooks the eyes must fit
• Wire rope sling – where the environment, not the load, გადაწყვეტს
• მრგვალი სლინგი – for a load that must not be marked at all