Lift sling rigging company produce 2000KG Single Use Lifting Slings,2000kg Lifting Slings,2Ton Single-use flat sling,2000kg Flat Webbing Slings,2000kg Single Use Slings,2Tonne one way lifting sling.
2000KG Single Use Lifting Slings
- 2,000 κιλάWLL, vertical hitch
- 1,600 κιλάWLL, choker hitch
- 4,000 κιλάWLL, basket hitch
- 60 / 30 mmΠλάτος ιστού, μονόκλινο / διπλό φύλλο
Single use describes the journey and the purchase, not a lower grade of band. Το πλάτος, the factor and the marking are specified exactly as they are for a sling that will work for years, because the one lift still has to be a rated lift. If you need the same band rated for repeat service, ο σφεντόνα ατελείωτου τύπου covers that case; this page is about the one-way build.
Ο 2000 kg line at a glance
Both constructions carry the same rating. What changes is the shape of the band, and that is the decision most buyers actually make.
| Παράμετρος | Μονόφυλλο | Double ply |
|---|---|---|
| Όριο φορτίου εργασίας, κατακόρυφος | 2,000 κιλά | 2,000 κιλά |
| Όριο φορτίου εργασίας, σφικτό περιδέραιο | 1,600 κιλά | 1,600 κιλά |
| Όριο φορτίου εργασίας, καλάθι | 4,000 κιλά | 4,000 κιλά |
| Πλάτος ιστού | 60 mm | 30 mm |
| Πάχος πλέγματος | 7.5 mm | 15 mm |
| Ελάχιστο μήκος | 1.2 m | 1.5 m |
| Weight of band | 0.45 kg/m | 0.50 kg/m |
| Κωδικός χρώματος (ΣΕ 1492-1) | Πράσινος | Πράσινος |
| Συντελεστής σχεδίασης | 7:1 | 7:1 |
60 mm single ply or 30 mm double ply
The rating is identical, so choose on handling and on the surface being lifted.
Μονόφυλλο, 60 mm πλάτος
- Load spread over a wider face — the better default for finished surfaces, painted steel and dressed timber.
- Thin enough to lie flat under a pack and to be inspected by feel along its length.
- Shows abrasion earlier, which is an advantage on a one-trip sling: damage appears where you can see it.
Double ply, 30 mm πλάτος
- Two layers of the same webbing, so twice the thickness in half the width — it threads through tight eye bolts and shackle bows that a 60 mm band will not enter.
- More abrasion reserve where the band crosses a sharp arris.
- Stiffer to handle and slightly heavier per metre.
If the lift is a bundle of steel bars, choose single ply. If it is a machined shaft through a narrow eye, choose double ply. Both are 2 t; neither is the “ισχυρότερος” ένας.
Μήκος, weight and packing
Band weight follows directly from the metre rate, which matters when you are air-freighting a few hundred slings or checking a carton against a customs declaration.
| Μήκος | Μονόφυλλο | Double ply |
|---|---|---|
| 1.2 m | 0.54 κιλά | — |
| 1.5 m | 0.68 κιλά | 0.75 κιλά |
| 2 m | 0.90 κιλά | 1.00 κιλά |
| 3 m | 1.35 κιλά | 1.50 κιλά |
| 4 m | 1.80 κιλά | 2.00 κιλά |
| 6 m | 2.70 κιλά | 3.00 κιλά |
| 8 m | 3.60 κιλά | 4.00 κιλά |
| 10 m | 4.50 κιλά | 5.00 κιλά |
Each sling is folded, bagged and carton-boxed; larger orders are palletised. For a 2000 kg band the packed weight runs about 15–20 % above the figures above once bags, labels and cartons are counted — use the carton weight on the packing list for freight, not the band weight.
Reading the colour, and the number beside it
ΣΕ 1492-1 assigns a colour to each working load limit so a supervisor can spot a wrong sling from a distance. Green means two tonnes in that code. The colour is a check, not the authority: the label states WLL, μήκος, batch and standard, and the lift plan is built from the label.
| WLL | Χρώμα (ΣΕ 1492-1) | Πλάτος ιστού | Ελάχιστο μήκος |
|---|---|---|---|
| 1,000 κιλά | Βιολέτα | 30 mm | 1.1 m |
| 2,000 κιλά | Πράσινος | 60 mm | 1.2 m |
| 3,000 κιλά | Κίτρινος | 90 mm | 1.3 m |
| 4,000 κιλά | Γκρί | 120 mm | 1.4 m |
| 5,000 κιλά | Κόκκινος | 150 mm | 2.0 m |
| 6,000 κιλά | Καστανός | 180 mm | 2.0 m |
| 8,000 κιλά | Μπλε | 240 mm | 2.0 m |
| 10,000 κιλά | Πορτοκάλι | 300 mm | 3.0 m |
| 12,000 κιλά | No standard colour | 300 mm | 3.0 m |
Πάνω από 12 t the range continues in double ply to 24 t, where the colour code no longer applies and the label carries the rating alone. The full spread of formats is listed under single use slings.
Τι το 2 t rating becomes in each hitch
The number on the label is a vertical rating. Two other hitches are in common use and both change the figure before any dynamic effect is considered.
| Αναποδιά | WLL | When it applies |
|---|---|---|
| Κατακόρυφος | 2,000 κιλά | Μονό πόδι, hook to load, no wrap-around |
| Σφικτό περιδέραιο | 1,600 κιλά | Band passed round the load and through its own eye |
| Καλάθι, πόδια κάθετα | 4,000 κιλά | Μπάντα κάτω από το φορτίο, both eyes to the hook |
| Καλάθι, 45° leg angle | 2,800 κιλά | Two legs opening as the load spreads |
| Καλάθι, 90° leg angle | 2,000 κιλά | Wide load, legs almost horizontal |
A choker costs you a fifth of the rating, which is why a 2 t sling is often bought where the arithmetic says 1.6 t. Decide the hitch before you decide the tonnage.
Μάτια, sleeves and the places a band dies
The eyes are where a one-trip sling usually fails, so they are worth specifying rather than accepting.
- Επίπεδο μάτι, sewn. The standard finish: the band is folded back and stitched, giving a soft eye that conforms to a hook.
- Ενισχυμένο μάτι. An extra wrap of webbing or a red sleeve over the eye, as on the white sling below, takes the abrasion that a steel hook or a shackle pin would otherwise take from the band.
- Wear sleeve on the body. A loose sleeve slid over the contact point, for loads with a known arris.
- Προστασία άκρων. Separate pads or corner guards, used with the sling rather than sewn into it.
Polyester is rated from −40 °C to +100 °C and resists most oils and solvents; it is attacked by concentrated acids and by alkalis at strength. It also stretches less than nylon under the same load, which is why a 2 t polyester band is the usual choice where the load must not sink after it leaves the ground. Cones, hooks and shackles that go with the band are listed under συσκευές ανύψωσης.
Βαθμολόγηση, and what has to be on the label
Every sling leaves with a sewn label carrying the working load limit, το μήκος, το υλικό, the batch number, the design factor and the standard it was made to. The band is also printed with WLL in figures large enough to read from the ground, because the label is under the load once the lift starts.
- Batch traceability. The batch number on the label ties back to the webbing roll and the test record, which is what an auditor asks for when a one-trip sling is used on a project.
- Σήμανση CE. Applies to the 7:1 series under Directive 2006/42/EC. Other design factors are supplied with type-test reports instead, so state the factor on the enquiry if CE matters to your market.
- Απόδειξη με έγγραφα. Batch material certificate, test report and declaration of conformity travel with the shipment. Certification scope is set out under πιστοποίηση.
- Private label. Your own label layout and part numbers can be printed, provided WLL and standard stay legible.
Μίας χρήσης, and what it does not excuse
Buyers come to this page for one reason: they want a 2000KG single use lifting sling rated for one lift, without paying for a band that will last ten years. That is a reasonable purchase, and the cost saving is real — it comes from the paperwork, the packaging and the fact that nobody will inspect the sling again, not from a thinner band.
Three things do not change on a one-way sling:
- The working load limit is still a limit, and the hitch still derates it.
- The sling still has to be inspected before the lift — one trip is one trip, not zero checks.
- The band still has to be stored away from heat, sunlight and chemicals between the factory and the lift, because polyester loses strength long before it looks damaged.
If the sling is coming back into stock and will be used again, buy the repeat-service webbing sling αντί. The two products look alike and are not interchangeable in a safety system.
Ordering a 2000KG single use lifting sling
Six lines on an enquiry are enough to quote and to make the sling correctly the first time:
- Rating and build: 2000 κιλά, μονόφυλλο 60 mm or double ply 30 mm.
- Μήκος: between the inside of the eyes, π.χ. 2.5 m.
- Τελειώνει: flat eye both ends, or one eye and one hook; reinforced eyes if the hooks are steel.
- Προστασία: sleeves, pads, or none.
- Βαθμολόγηση: standard label or private label; CE required or type-test report only.
- Quantity and destination: pieces, and the port or door the cartons go to.
Send the list through contact us and the reply comes back with the band width, the length tolerance and the carton weight, so the freight can be calculated before the order is placed. For containerised loads that need lashing rather than lifting, ο πρόσδεση φορτίου range uses the same webbing on a different rating basis, and should not be substituted for a lifting sling.
Συχνές ερωτήσεις
How much does a 2000KG single use lifting sling weigh?
Για 0.45 kg per metre in single ply and 0.50 kg per metre in double ply, έτσι α 2 m single ply sling is roughly 0.9 kg of band. Packed weight is 15–20 % higher once the bag, label and carton are counted.
Why is the 2 t sling green?
Green is the EN 1492-1 colour for a two tonne working load limit. It lets a supervisor check a sling at a glance, but the label governs — the colour is not a rating.
Is double ply stronger than single ply at the same tonnage?
Οχι. Both builds are rated 2,000 κιλά. Double ply packs the same strength into half the width and twice the thickness; single ply spreads it over a wider face. Choose on the eye you have to pass through and the surface you are lifting.
What is the minimum length?
1.2 m in single ply and 1.5 m in double ply, measured between the inside of the eyes. Below that the eye splice takes up too much of the band to sew a reliable joint.
Can one sling be used for several lifts?
A single use sling is bought for one consignment and is not normally recovered, inspected and returned to service. If it is coming back, specify a repeat-service sling with the same rating and keep it in an inspection regime.
Πού να πάτε μετά
- Μονόδρομος σφεντόνα — the whole category, by tonnage and format.
- Single use slings — the range this 2 t sling belongs to.
- Ιμάντες ατελείωτου τύπου — same band, loop construction, repeat service.
- Ατελείωτες ιμάντες ανύψωσης — round slings for loads that need a soft, conforming choke.
- Webbing sling manufacture — how the band, the stitch and the label are made.
- Σχετικά με εμάς — the factory behind the label.
Data note: band dimensions, metre weights and minimum lengths follow the published 2 t rows of the standard size table (single ply and double ply). Weights by length in Table 2 are calculated from those metre rates. Hitch figures in Table 4 apply the standard leg-angle factors to the published basket rating.